October 23, 2012

Records detail past problems at firm linked to meningitis

Investigators in 2006 found inadequate contamination control and no written standard operating procedures for using equipment, among other problems.

Bob Salsberg / The Associated Press

BOSTON — New state documents detail problems found in 2006 by an outside firm hired to do an assessment at the company at the center of a deadly meningitis outbreak.

click image to enlarge

Federal agents investigate the offices of New England Compounding Center in Framingham, Mass., on Oct. 16, 2012. The company's steroid medication has been linked to a deadly meningitis outbreak.


Related headlines

The state documents, obtained by The Associated Press under a public records request, say investigators in 2006 found inadequate contamination control and no written standard operating procedures for using equipment, among other problems, at the New England Compounding Center. The problems were corrected that year, and a state inspection in May 2011 as the company prepared to update its facilities found no such issues.

The outbreak of meningitis, an inflammation of the lining of the brain and spinal cord, has sickened nearly 300 people, including 23 who died, in more than a dozen states. Each victim had received a steroid shot, mostly for back pain. Federal health officials matched the shots produced by the company to the outbreak after finding a deadly fungus in more than 50 unopened vials there but have not said how the shots were contaminated.

A congressional committee on Monday sought a decade's worth of records from the company.

In a letter sent Monday to a lawyer for NECC, the House Committee on Energy and Commerce seeks nearly 10 years of documents about safety and quality issues at the company. It indicates that as far back as 2002 and 2003 officials from the Food and Drug Administration and the state conducted joint probes of the company after receiving a report about a steroid shot. Those probes preceded a 2004 joint investigation of the center by FDA and the Massachusetts Board of Registration in Pharmacy.

In January 2006, based on several complaints, the company signed with state regulators a consent agreement in which it agreed to a full inspection of its drug compounding practices by investigators.

The company's encounters with regulators have been reported since the outbreak began, but state pharmacy board documents released Monday offer a new level of detail. They show the inspection by Illinois-based Pharmaceutical Systems Inc. found "significant gaps" in procedures and a lack of required documentation at the NECC facility in Framingham, just west of Boston.

In a letter to pharmacist Barry Cadden, who co-founded NECC in 1998, PSI said it was "the opinion of the auditors that your operation needs to be upgraded and enhanced to be in substantial compliance" with federal pharmacy regulations.

"The auditors observed some of the compounding activities and although the technicians appeared to be performing the operation adequately, without a written procedure to follow it is not known if the activity is repeatable and reliable; and as noted throughout the report much of the documentation for the activities that is performed is inadequate," wrote Mick Moriva, vice president of quality operations for PSI.

The report found insufficient documentation that proper sterilization procedures had been followed.

Inspectors who looked at the company's non-sterile compounding procedures found potential contamination problems ranging from uncovered and unlabeled containers to a large hole in a ceiling panel above a workbench. The exteriors of some equipment were visibly dirty with buildups of residue.

In April 2006, George Cayer, then-president of the state pharmacy board charged with regulating the compounding industry, sent a follow-up letter to Cadden praising the company's progress in responding to the inspection.

"As you are aware, PSI states that NECC has made significant improvements over the past months and demonstrated the ability to be compliant with state and federal regulations. The Board commends NECC on the progress to date," Cayer wrote.

(Continued on page 2)

Were you interviewed for this story? If so, please fill out our accuracy form

Send question/comment to the editors

Further Discussion

Here at OnlineSentinel.com we value our readers and are committed to growing our community by encouraging you to add to the discussion. To ensure conscientious dialogue we have implemented a strict no-bullying policy. To participate, you must follow our Terms of Use.

Questions about the article? Add them below and we’ll try to answer them or do a follow-up post as soon as we can. Technical problems? Email them to us with an exact description of the problem. Make sure to include:
  • Type of computer or mobile device your are using
  • Exact operating system and browser you are viewing the site on (TIP: You can easily determine your operating system here.)