January 12, 2013

SAD 54 expects big savings from federally funded wood pellet boiler in Skowhegan

$1.7 million system to heat Skowhegan Area High School complex, expected to save $60,000 to $100,000 annually in fuel costs

By Doug Harlow dharlow@centralmaine.com
Staff Writer

SKOWHEGAN -- How do you keep 1,500 students warm in school all winter and still save money?

click image to enlarge

SAD 54 Superintendent Brent Colbry speaks in front of the new wood pellet boiler system inside Skowhegan Area High School on Thursday. Colbry said the efficient system could be paid for in fuel savings over the next 10 years.

Staff photo by David Leaming

click image to enlarge

Trevor Lawlor works on the wood pellet storage silo outside the Skowhegan Area High School on Thursday.

Staff photo by David Leaming

The answer is to install a modern biomass boiler that will heat three district schools using locally produced wood pellets.

"It's unique in that it's serving multiple schools, it has a local wood source and, of course, the cost savings," School Administrative District 54 Superintendent Brent Colbry said. "We dug trenches last summer from the high school to Bloomfield Elementary and then over to the middle school for insulated pipes. They're all connected underneath."

The equipment for the district's $1.7 million wood pellet boiler system arrived in a snowstorm the day after Christmas. The $500,000 Hurst pellet boiler is in the basement of Skowhegan Area High School. It is fed with an auger from a 42-ton silo on the east side of the high school, by the football field.

The system runs off of a 3,500-gallon hot water tank, warmed by the wood pellets and circulated in a loop to every room in all three schools, Colbry said.

The school board approved the project in January 2012. State education officials and the local school board already had approved a borrowing package of up to about $2 million, at low interest, for a wood pellet boiler system.

Colbry said Messalonskee High School and two other schools in Oakland-based Regional School Unit 18 did something similar with a boiler that burns wood chips. Schools in North Anson-based SAD 74 use pellet boilers, as do schools in Waterville, Farmington, Unity, Philips and Dexter. SAD 59's Madison Area Memorial High School has installed a geothermal heating system, which taps energy from underground.

Colbry said the wood pellet project was paid for with a low-interest loan from the federal government, under President Barack Obama's stimulus package.

"The pay back will come from the savings from the oil," he said. "You take the cost of the loan, you take the cost of the pellets and the cost of the boiler, compared to what we were spending on oil before -- we're saving between $60,000 and $100,000 a year."

SAD 54 has a five-year contract with the Maine Woods Pellet Co. in Athens. Colbry said the boiler will burn about 600 tons of wood pellets per year, at $175 per ton, or about $105,000.

The oil equivalent would be twice the cost, he said. He said the loan should be paid off in 10 years.

Colbry said the school board also authorized additional connections to accommodate natural gas, if those plans ever take shape and arrive in Skowhegan. Two existing oil-fired boilers will remain in place in each of the schools' basements for backup and to make hot water during the warmer months, because wood pellet boilers overheat in the spring and fall. There also are propane hot-water heaters in each school.

Colbry said the system is expected to be test-fired at the end of the month and fully operational by the first week of February.

The other towns in SAD 54 are Canaan, Cornville, Mercer, Norridgewock and Smithfield.

Doug Harlow -- 612-2367
dharlow@centralmaine.com

 

Were you interviewed for this story? If so, please fill out our accuracy form

Send question/comment to the editors




Further Discussion

Here at OnlineSentinel.com we value our readers and are committed to growing our community by encouraging you to add to the discussion. To ensure conscientious dialogue we have implemented a strict no-bullying policy. To participate, you must follow our Terms of Use.

Questions about the article? Add them below and we’ll try to answer them or do a follow-up post as soon as we can. Technical problems? Email them to us with an exact description of the problem. Make sure to include:
  • Type of computer or mobile device your are using
  • Exact operating system and browser you are viewing the site on (TIP: You can easily determine your operating system here.)